© The Institution of Engineering and Technology
This Letter reports the synthesis of nanoceramic composite ZnAl2O4TiO2 by using a cost-effective and straight forward sol–gel route. X-ray diffraction (XRD) showed the ZnAl2O4 cubic structure along with the mixed anatase- and rutile-phases of TiO2. Rietveld refinement is performed using XRD pattern to study the structural parameters. Raman investigation endorsed the corresponding vibration peaks of TiO2 and ZnO. Field-emission scanning electron microscopy evidenced the agglomerated spherical nanoparticles. Energy-dispersive spectroscopy analysis demonstrated the elementary peaks of Zn, Al, and Ti at 4.5, 1.5, and 1 eV, respectively. LCR measurement revealed the decreased dielectric permittivity with the rise in frequency and temperature. This dielectric characteristic is attributed to the dipole movement of the charge carriers. Furthermore, the authors present the investigation of the conductivity and impedance of the prepared dielectric ceramic material.
References
-
-
1)
-
14. Surendran, K.P., Sebastian, M.T., Manjusha, M.V., et al: ‘A low loss, dielectric substrate in ZnAl2O4 – TiO2 system for microelectronic applications’, J. Appl. Phys., 2005, 98, (4), p. 044101 (doi: 10.1063/1.2007873).
-
2)
-
26. Muhammad Abdul Jamal, E., Sakthi Kumar, D., Anantharaman, M.R.: ‘On structural, optical and dielectric properties of zinc aluminate nanoparticles’, Bull. Mater. Sci., 2011, 34, (2), pp. 251–259 (doi: 10.1007/s12034-011-0071-y).
-
3)
-
22. Jalal, W.N.W., Abdullah, H., Zulfakar, M.S., et al: ‘Synthesis and fabrication of GPS patch antennas by using Zn(1 − x)TixAl2O4 thin films’, J. Sol-Gel Sci. Technol., 2015, 74, (2), pp. 566–574 (doi: 10.1007/s10971-015-3673-9).
-
4)
-
12. Jalal, W.N.W., Abdullah, H., Zulfakar, M.S.: ‘Characterization and dielectric properties of novel dielectric ceramics CaxZn(1−x)Al2O4 for GPS patch antennas’, Int. J. Appl. Ceram. Technol., 2013, 12, pp. 1–11.
-
5)
-
3. de Macedo, H.P., de Araujo Medeiros, R.L.B., de Medeiros, A.L., et al: ‘Characterization of ZnAl2O4 spinel obtained by hydrothermal and microwave assisted combustion method: a comparative study’, Mater. Res., 2017, 20, (2), pp. 29–33 (doi: 10.1590/1980-5373-mr-2016-0977).
-
6)
-
4. Battiston, S., Rigo, C., da Cruz Severo, E., et al: ‘Synthesis of zinc aluminate (ZnAl2O4) spinel and its application as photocatalyst’, Mater. Res., 2014, 17, (3), pp. 734–738 (doi: 10.1590/S1516-14392014005000073).
-
7)
-
30. Shang-Pan, H., Zhi-Qiang, W., Xiao-Juan, W., et al: ‘Optical properties of Cr doped ZnAl2O4 nanoparticles with spinel structure synthesized by hydrothermal method’, Mater. Res. Express, 2020, 7, (1), p. 015025 (doi: 10.1088/2053-1591/ab6125).
-
8)
-
10. Wang, X., Lei, W., Lu, W.: ‘Novel ZnAl2O4-based microwave dielectric ceramics with machinable property and its application for GPS antenna’, Ferroelectrics, 2009, 388, pp. 80–87 (doi: 10.1080/00150190902964060).
-
9)
-
23. Abdalla, Z.E.A., Kumar, M., Hassan, I., et al: ‘An improvised method for the synthesis of ZnAl2O4/ZnO nanocomposite and its use as a photo catalyst’, J. Mater. Sci., Mater. Electron., 2018, 29, pp. 1–8.
-
10)
-
29. Macedo, H.P., Medeiros, R.L.B.A., Nascimento, R.A.B., et al: ‘Study of ZnAl2O4 spinel nanoparticles synthesized using gelatin as organic precursor’, Cerâmica, 2019, 65, pp. 180–184 (doi: 10.1590/0366-69132019653742620).
-
11)
-
13. Lei, W., Lu, W.-Z., Zhu, J.-H., et al: ‘Microwave dielectric properties of ZnAl2O4-TiO2 spinel-based composites’, Mater. Lett., 2007, 61, pp. 4066–4069 (doi: 10.1016/j.matlet.2007.01.017).
-
12)
-
16. Wu, J.-M., Lu, W.-Z., Lei, W., et al: ‘Preparation of ZnAl2O4 – based microwave dielectric ceramics and GPS antenna by aqueous gel casting’, Mater. Res. Bull., 2011, 46, (9), pp. 1485–1489 (doi: 10.1016/j.materresbull.2011.04.026).
-
13)
-
6. Maleki, A.: ‘One-pot multicomponent synthesis of diazepine derivatives using terminal alkynes in the presence of silica-supported superparamagnetic iron oxide nanoparticles’, Tetrahedron Lett., 2013, 54, pp. 2055–2059 (doi: 10.1016/j.tetlet.2013.01.123).
-
14)
-
24. Wang, S.-F., Sun, G.-Z., Fang, L.-M., et al: ‘A comparative study of ZnAl2O4 nanoparticles synthesized from different aluminum salts for use as fluorescence materials’, Sci. Rep., 2015, 5, (1), pp. 1–12.
-
15)
-
17. Surendran, K.P., Santha, N., Mohanan, P., et al: ‘Temperature stable low loss ceramic dielectrics in (1-x)ZnAl2O4-xTiO2 system for microwave substrate applications’, Eur. Phys. J. B, 2004, 41, (3), pp. 301–306 (doi: 10.1140/epjb/e2004-00321-8).
-
16)
-
35. So, W.W., Park, S.B., Kim, K.J., et al: ‘The crystalline phase stability of titania particles prepared at room temperature by the sol-gel method’, J. Mater. Sci., 2001, 36, (17), pp. 4299–4305 (doi: 10.1023/A:1017955408308).
-
17)
-
11. Lei, W., Lu, W.-Z., Zhu, J.-H., et al: ‘Effects of heating rate on microstructures and microwave dielectric properties of (1 − x)ZnAl2O4–xTiO2 (x = 0.21) ceramics’, Ceram. Int., 2009, 35, pp. 277–280 (doi: 10.1016/j.ceramint.2007.10.021).
-
18)
-
25. Li, Z., Xing, L., Zhang, N., et al: ‘Preparation and photocatalytic property of TiO2 columnar nanostructure films’, Mater. Trans., 2011, 52, (10), pp. 1939–1942 (doi: 10.2320/matertrans.MAW201104).
-
19)
-
6. Maleki, A.: ‘Green oxidation protocol: selective conversions of alcohols and alkenes to aldehydes, ketones and epoxides by using a new multiwall carbon nanotube-based hybrid nanocatalyst via ultrasound irradiation’, Ultrason. Sonochem., 2018, 40, pp. 460–464 (doi: 10.1016/j.ultsonch.2017.07.020).
-
20)
-
2. Farhadi, S., Panahandehjoo, S.: ‘Spinel-type zinc aluminate (ZnAl2O4) nanoparticles prepared by the co-precipitation method: a novel, green and recyclable heterogeneous catalyst for the acetylation of amines, alcohols and phenols under solvent-free conditions’, Appl. Catal. A, Gen, 2010, 382, pp. 293–302 (doi: 10.1016/j.apcata.2010.05.005).
-
21)
-
5. Maleki, A.: ‘One-pot three-component synthesis of pyrido[20,10:2,3]imidazo[4,5-c]isoquinolines using Fe3O4@SiO2–OSO3H as an efficient heterogeneous nanocatalyst’, RSC Adv., 2014, 4, pp. 64169–64173 (doi: 10.1039/C4RA10856F).
-
22)
-
34. Obada, D., Dodoo-Arhin, D., Dauda, M., et al: ‘Effect of mechanical activation on mullite formation in an alumina- silica ceramics system at lower temperature’, World J. Eng., 2016, 13, (4), pp. 288–293 (doi: 10.1108/WJE-08-2016-039).
-
23)
-
18. Abdullah, H., Zulfakar, M.S., Jalal, W.N.W., et al: ‘Synthesis and fabrication of (1-x)ZnAl2O4–xSiO2 thin films to be applied as patch antennas’, J. Sol-Gel. Sci. Technol., 2014, 69, pp. 183–192 (doi: 10.1007/s10971-013-3202-7).
-
24)
-
15. Huang, C.-L., Yang, T.-J., Huang, C.-C.: ‘Low dielectric loss ceramics in the ZnAl2O4–TiO2 system as a λf compensator’, J. Am. Ceram. Soc., 2009, 92, (1), pp. 119–124 (doi: 10.1111/j.1551-2916.2008.02827.x).
-
25)
-
21. Sahib, A.K.S.K.A, Suganthi, M., Sivabharathy, M., et al: ‘Synthesis of double lanthanide doped nano ferrite meta material for microstrip patch antenna application’, Int. J. ChemTech Res. CODEN (USA), IJCRGG, 2014, 6, (11), pp. 4615–4624.
-
26)
-
20. Raja, K., John Pragasam, D., Naidu, V.: ‘Synthesis of lanthanum doped magnesium ferrite as jointed substrate material to design and develop micro strip patch antenna for ISM band application’, IOSR J. Mech. Civ. Eng., 2014, 3, pp. 59–64.
-
27)
-
1. Mohaqeq, M., Safaei-Ghomi, J., Shahbazi-Alavi, H., et al: ‘ZnAl2O4 nanoparticles as efficient and reusable heterogeneous catalyst for the synthesis of 12-phenyl-8,12-dihydro-8,10-dimethyl-9H-naphtho [1′,2′:5,6] pyrano [2,3-d] pyrimidine-9,11-(10H)-diones under microwave irradiation’, Polycyclic Aromat. Compd., 2017, 37, (1), pp. 52–62 (doi: 10.1080/10406638.2015.1088044).
-
28)
-
27. Thinesh Kumar, R., Clament Sagaya Selvam, N., Raghupathi, C., et al: ‘Synthesis, characterization and performance of porous Sr(II)-added ZnAl2O4 nanomaterials for optical and catalytic applications’, Powder Technol., 2012, 224, pp. 147–154 (doi: 10.1016/j.powtec.2012.02.044).
-
29)
-
33. Rashad, M., Pan, F., Tang, A., et al: ‘Effects of grapheen nanoplatelets addition on mechanical properties of pure aluminium using a semi powder method’, Prop. Nat. Sci. Mater. Int., 2014, 24, (2), pp. 101–108 (doi: 10.1016/j.pnsc.2014.03.012).
-
30)
-
5. Maleki, A., Ravaghi, P., Movahed, H.: ‘Green approach for the synthesis of carboxycoumarins by using a highly active magnetically recyclable nanobiocomposite via sustainable catalysis’, Micro Nano Lett., 2018, 13, (5), pp. 591–594 (doi: 10.1049/mnl.2017.0560).
-
31)
-
28. Salem, S.: ‘Effect of fuel content on formation of zinc aluminate nano and micro-particles synthesised by high rate sol–gel autoignition of glycine-nitrates’, Chem. Pap., 2016, 70, (3), pp. 356–364 (doi: 10.1515/chempap-2015-0205).
-
32)
-
31. Hebbar, D.N., Menon, S.G., Choudhari, K.S., et al: ‘Cr-doped ZnAl2O4: microwave solution route for ceramic nanoparticles from metalorganic complexes in minutes’, J. Am. Ceram. Soc., 2017, 101, (2), pp. 800–811 (doi: 10.1111/jace.15256).
-
33)
-
32. Castrejón-Sánchez, V.H., Camps, E., Camacho-López, M.: ‘Quantification of phase content in TiO2 thin films by Raman spectroscopy’, Superf. Vacío, 2014, 27, (3), pp. 88–92.
-
34)
-
8. Maleki, A., Hajizadeh, Z., Sharifi, V., et al: ‘A green, porous and eco-friendly magnetic geopolymer adsorbent for heavy metals removal from aqueous solutions’, J. Cleaner Prod., 2019, 2015, pp. 1233–1245 (doi: 10.1016/j.jclepro.2019.01.084).
-
35)
-
19. Zulfakar, M.S., Abdullah, H., Islam, M.T., et al: ‘Performance effect of ZnAl2O4 - SiO2 thin film for wireless patch antenna application’, J. Nano Res., 2014, 28, pp. 141–150 (doi: 10.4028/www.scientific.net/JNanoR.28.141).
http://iet.metastore.ingenta.com/content/journals/10.1049/mnl.2020.0266
Related content
content/journals/10.1049/mnl.2020.0266
pub_keyword,iet_inspecKeyword,pub_concept
6
6