Epoxy nanocomposites being used in the high-energy radiation zones as an insulant may undergo changes in their dielectric properties during service. In the present study, the performance of base epoxy resin (S1) is compared with epoxy resin with ion trapping particle (Sample S2) and epoxy resin with nanotitania (Sample S3) particle. The influence of gamma irradiation on nanocomposites was analysed. Corona inception voltage due to water droplet initiated discharge and contact angle reduces post-gamma-ray irradiation. Surface potential decay time constant reduced drastically for gamma-ray-irradiated specimens. Trap distribution characterisation indicated that charge mobility increases after irradiation. The surface roughness of the sample increases with the irradiation dosage. Dielectric relaxation spectroscopy shows that permittivity reduces and loss tangent increases with the gamma-irradiated specimens. Water diffusion rate increases for the gamma-ray-irradiated specimen. No change in elemental composition, measured using laser-induced breakdown spectroscopy, of test specimens was observed. The hardness of the material and plasma temperature formed during laser shine decreases with gamma-ray irradiation intensity for Sample S1, whereas samples S2 and S3 showed only marginal variation. The performance of Sample S2 is found to be better than Samples S1 and S3.

References

1. 1)
  - 12. Murray, K.A., Kennedy, J.E., McEvoy, B., et al: ‘Effects of gamma ray and electron beam irradiation on the mechanical, thermal, structural and physicochemical properties of poly (ether-block-amide) thermoplastic elastomers’, J. Mech. Behav. Biomed. Mater., 2012, 81, pp. 252–268.
2. 2)
  - 18. Gao, Y., Du, B.X., Ma, Z.L., et al: ‘Decay behavior of surface charge on gamma-ray irradiated epoxy resin’. Proc. IEEE Int. Conf. Solid Dielectrics (ICSD), Potsdam, Germany, 2010, pp. 1–4.
3. 3)
  - 86. Cao, Y., Irwin, P.C., Younsi, K.: ‘The future of nanodielectrics in the electrical power industry’, IEEE Trans. Dielectr. Electr. Insul., 2004, 11, (5), pp. 797–807 (doi: 10.1109/TDEI.2004.1349785).
4. 4)
  - 6. Nelson, J.K., Hu, Y., Thiticharoenpong, J.: ‘Electrical properties of TiO2 nanocomposites’. IEEE Conf. Electrical Insulation Dielectric Phenomena (CEIDP), Albuquerque, NM, USA, 2003, pp. 719–722.
5. 5)
  - 5. Yong-Hong, C., Zeng-Bin, W., KaiStudy, W.: ‘Pulsed vacuum surface flashover characteristics of epoxy composites with micro TiO2 and Al2O3.3H2O filler’, IEEE Trans. Plasma Sci., 2012, 40, (1), pp. 68–77 (doi: 10.1109/TPS.2011.2172468).
6. 6)
  - 30. Du, B.X., Zhang, J.W., Gao, Y.: ‘Effects of TiO2 particles on surface charge of epoxy nanocomposites’, IEEE Trans. Dielectr. Electr. Insul., 2012, 19, (3), pp. 755–762 (doi: 10.1109/TDEI.2012.6215077).
7. 7)
  - 14. Sarathi, R., Mishra, P., Gautam, R., et al: ‘Understanding water droplet initiated discharges on damage caused to corona aged silicone rubber’, IEEE Trans. Dielectr. Electr. Insul., 2017, 24, (4), pp. 2421–2431 (doi: 10.1109/TDEI.2017.006546).
8. 8)
  - 15. Kumara, S., Serdyuk, Y.V., Gubanski, S.M.: ‘Surface charge decay on polymeric materials under different neutralization model in air’, IEEE Trans. Dielectr. Electr. Insul., 2011, 18, (5), pp. 1779–1788 (doi: 10.1109/TDEI.2011.6032850).
9. 9)
  - 24. Crank, J.: ‘Mathematics of diffusion’ (Oxford Science Publications, New York, NY, 1975, 2nd edn.).
10. 10)
  - 23. Johnscher, A.K.: ‘Dielectric relaxation in solids’ (Chelsea Dielectrics Press, London, UK, 1983).
11. 11)
  - 4. Singha, S., Thomas, M.J.: ‘Dielectric properties of epoxy nanocomposites’, IEEE Trans. Dielectr. Electr. Insul., 2008, 15, (1), pp. 373–385.
12. 12)
  - 10. Amphlett, C., McDonald, L., Redman, M.: ‘Synthetic inorganic ion-exchange materials-I zirconium phosphate’, J. Inorg. Nucl. Chem., 1958, 6, (3), pp. 220–235 (doi: 10.1016/0022-1902(58)80152-9).
13. 13)
  - 11. Kyoto, M., Chigusa, Y., Ohe, M., et al: ‘Gamma-ray radiation hardened properties of pure silica core single-mode fiber and its data link system in radioactive environments’, J. Lightwave Technol., 1992, 10, (3), pp. 289–294 (doi: 10.1109/50.124489).
14. 14)
  - 21. Meyer, L.H., Jayaram, S.H., Cherney, E.A.: ‘A novel technique to evaluate the erosion resistance of silicone rubber composites for high voltage outdoor insulation using infrared laser erosion’, IEEE Trans. Dielectr. Electr. Insul., 2005, 12, (6), pp. 1201–1208 (doi: 10.1109/TDEI.2005.1561800).
15. 15)
  - 22. Gorur, G.R.: ‘Dielectrics in electric fields’ (CRC Press Taylor and Francis Group, Boca Raton, FL, 2016), pp. 137–141.
16. 16)
  - 16. Ashwin Desai, B.M., Mishra, P., Vasa, N.J., et al: ‘Understanding the performance of corona aged epoxy nano micro composites’, Micro & Nano Letters, 2018, 13, (9), pp. 1280–1285 (doi: 10.1049/mnl.2018.0164).
17. 17)
  - 1. Iyer, G., Gorur, R.S., Richert, R., et al: ‘Dielectric properties of epoxy based nanocomposites for high voltage insulation’, IEEE Trans. Dielectr. Electr. Insul., 2011, 18, (3), pp. 659–666 (doi: 10.1109/TDEI.2011.5931050).
18. 18)
  - 2. Imai, T., Sawa, F., Nakano, T., et al: ‘Effects of nano and micro-filler mixture on electrical insulation properties of epoxy based composites’, IEEE Trans. Dielectr. Electr. Insul., 2006, 13, (1), pp. 319–326 (doi: 10.1109/TDEI.2006.1624276).
19. 19)
  - 34. Cowpe, J.S., Moorehead, R.D., Moser, D., et al: ‘Hardness determination of bio-ceramics using laser-induced breakdown spectroscopy’, Spectrochim. Acta B, 2011, 66, pp. 290–294 (doi: 10.1016/j.sab.2011.03.007).
20. 20)
  - 9. Kraus, K.A., Phillips, H.O.: ‘Adsorption on inorganic materials I. Cation exchange properties of zirconium phosphate’, J. Am. Chem. Soc., 1956, 78, (3), pp. 694–694 (doi: 10.1021/ja01584a053).
21. 21)
  - 23. Sarathi, R., Harsha, V.S., Griffiths, H., et al: ‘Understanding water droplet initiated discharges on epoxy nano composites under harmonic AC voltages adopting uhf technique’, IEEE Trans. Dielectr. Electr. Insul., 2014, 21, (2), pp. 918–925 (doi: 10.1109/TDEI.2013.004378).
22. 22)
  - 20. Molinié, P.: ‘Measuring and modeling transient insulator response to charging: the contribution of surface potential studies’, IEEE Trans. Dielectr. Electr. Insul., 2005, 12, (5), pp. 939–950 (doi: 10.1109/TDEI.2005.1522188).
23. 23)
  - 21. Laghari, J.R., Hammoud, A.N.: ‘A brief survey of radiation effects on polymer dielectrics’, IEEE Trans. Nucl. Sci., 1990, 37, (2), pp. 1076–1083 (doi: 10.1109/TNS.1990.574201).
24. 24)
  - 7. Katayama, J., Ohki, Y., Fuse, N., et al: ‘Effects of nanofiller materials on the dielectric properties of epoxy nanocomposites’, IEEE Trans. Dielectr. Electr. Insul., 2013, 20, (1), pp. 157–165 (doi: 10.1109/TDEI.2013.6451354).
25. 25)
  - 17. Imai, T., Sawa, F., Ozaki, T., et al: ‘Evaluation of insulation properties of epoxy resin with nano-scale silica particles’. Proc. Int. Symp. on Electrical Insulating Materials (ISEIM), Kitakyushu, Japan, 2005, No. A4-5, pp. 239–242.
26. 26)
  - 8. Singha, S., Thomas, M.J.: ‘Permittivity and tan delta characteristics of epoxy nanocomposites’, IEEE Trans. Dielectr. Electr. Insul., 2008, 15, (1), pp. 2–11 (doi: 10.1109/T-DEI.2008.4446731).

Understanding the performance of gamma-ray-irradiated epoxy nanocomposites

References

Related content