© The Institution of Engineering and Technology
Sensor count reduction for high-performance induction motor (IM) drives is considered. A novel strategy to compute the three phase currents, based on a single current sensor and an adaptive observer, is proposed. The observer estimates the motor state variables, allowing then implementing an IM field-oriented controlled (FOC) drive with closed speed loop based only on DC-link measurements. To demonstrate the practical feasibility of this proposal, representative experimental results, obtained with a FOC experimental prototype, are presented. The FOC prototype showed results similar to those from a conventional FOC drive with individual phase current sensors. The sensor count reduction achieved represents a significant cost diminution in the implementation of low-power high-performance drives.
References
-
-
1)
-
D.Ch. Lee ,
G.-M. Lee
.
A novel overmodulation technique for space-vector PWM inverters.
IEEE Trans. Power Electron.
,
1144 -
1151
-
2)
-
T.C. Green ,
B.W. Willliams
.
Derivation of motor line-current waveforms from DC-link current of an inverter.
IEE Proc., Electr. Power Appl.
,
197 -
204
-
3)
-
Y. Xue ,
X. Xu ,
T.G. Habetler ,
D.M. Divan
.
A stator flux-oriented voltage source variable-speed drive based on DC link measurement.
IEEE Trans. Ind. Appl.
,
5 ,
962 -
969
-
4)
-
Wolbank, T.M., Macheiner, P.: `An improved observer-based current controller for inverter fed AC machines with single DC-link current measurement', Proc. IEEE PESC, 2002, p. 1003–1008.
-
5)
-
W. Lee ,
T. Lee ,
D. Hyun
.
Comparison of single-sensor current control in the DC link for three-phase voltage-source PWM converters.
IEEE Trans. Ind. Electron.
,
3 ,
491 -
505
-
6)
-
H. Kubota ,
K. Matsuse ,
T. Nakano
.
DSP-based speed adaptive flux observer of induction motor.
IEEE Trans. Ind. Appl.
,
344 -
348
-
7)
-
F. Blaabjerg ,
J.K. Pedersen
.
A new low-cost, fully fault-protected PWM-VSI inverter with true phase-current information.
IEEE Trans. Power Electron.
,
1 ,
187 -
197
-
8)
-
J. Holtz
.
Pulsewidth modulation – a survey.
IEEE Trans. Ind. Electron.
,
5 ,
410 -
420
-
9)
-
Blaabjerg, F., Pedersen, J.K.: `An ideal PWM–VSI inverter using only one current sensor in the DC-link', Proc., 1994, IEEE PEVD, p. 458–464.
-
10)
-
A. Visioli
.
Modified anti-windup scheme for PID controllers.
IEE Proc. Control Theory Appl.
,
1 ,
49 -
54
-
11)
-
S. Suwankawin ,
S. Sangwoungwanich
.
A speed-sensorless IM drive with decoupling control and stability analysis of speed estimation.
IEEE Trans. Ind. Electron.
,
2 ,
444 -
455
-
12)
-
`Texas Instruments, Digital Motor Control Software Library', Lit. Num. SPRA485A, 2003.
-
13)
-
Joo, H.G., Kim, C., Shin, H., Youn, M.: `Detection of three-phase currents in space-vector PWM inverters with only one DC link current sensor', Proc. IEEE IECON, 1996, p. 127–132.
-
14)
-
`Texas Instruments, Three phase current measurements using a single line resistor on the TMS320F240', Lit. Num. BPRA077, 1998.
-
15)
-
M. Hinkkanen ,
J. Luomi
.
Stabilization of regenerating-mode operation in sensorless induction motor drives by full-order flux observer design.
IEEE Trans. Ind. Electron.
,
6 ,
1318 -
1328
-
16)
-
K. Rajashekara ,
A. Kawamura ,
K. Matsuse
.
(1996)
Sensorless Control of AC Motor Drives.
-
17)
-
G.C. Verghese ,
S.R. Sanders
.
Observer for flux estimation in induction machines.
IEEE Trans. Ind. Electron.
,
1 ,
85 -
94
-
18)
-
W.H. Press ,
B.P. Flannery ,
S.A. Teukolsky ,
W.T. Vetterling
.
(1992)
Numerical Recipes in C.
http://iet.metastore.ingenta.com/content/journals/10.1049/ip-epa_20050552
Related content
content/journals/10.1049/ip-epa_20050552
pub_keyword,iet_inspecKeyword,pub_concept
6
6