The development of microcrystalline silicon (μc-Si:H) for solar cells has made good progress with efficiencies better than those of amorphous silicon (a-Si:H) devices. Of particular interest is the absence of light-induced degradation in highly crystalline μc-Si:H. However, the highest efficiencies are obtained with material which may still include a-Si:H regions and light-induced changes may be expected in such material. On the other hand, material of high crystallinity is susceptible to in-diffusion of atmospheric gases which, through adsorption or oxidation, affect the electronic transport. Investigations are presented of such effects concerning the stability of μc-Si:H films and solar cells prepared by plasma-enhanced chemical vapour deposition and hot wire chemical vapour deposition.
References
-
-
1)
-
L. Houben ,
M. Luysberg ,
P. Hapke ,
R. Carius ,
F. Finger ,
H. Wagner
.
Structural properties of microcrystalline silicon in the transition from highly crystalline to amorphous growth.
Philos. Mag. A
,
1447 -
1460
-
2)
-
Wang, C., Lucovsky, G.: `Intrinsic microcrystalline silicon deposited by remote PECVD: a new thin-film photovoltaic material', Proc. 21st IEEE Photovoltaic Specialists Conf., 1990, Kissikimee, FL, USA, p. 1614–1618.
-
3)
-
J. Meier ,
R. Flückiger ,
H. Keppner ,
A. Shah
.
Complete microcrystalline p-i-n solar cell-crystalline or amorphous cell behavior?.
Appl. Phys. Lett.
,
860 -
862
-
4)
-
J. Müller ,
F. Finger ,
R. Carius ,
H. Wagner
.
Electron spin resonance investigation of electronic states in hydrogenated microcrystalline silicon.
Phys. Rev. B
,
11666 -
11677
-
5)
-
S. Vepřek ,
Z. Iqpal ,
R.O. Kühne ,
P. Capezzuto ,
F.-A. Sarott ,
J.K. Gimzewski
.
Properties of microcrystalline silicon. IV. Electrical conductivity, electron spin resonance and the effect of gas adsorption.
J. Phys. C, Solid State Phys.
,
2641 -
264
-
6)
-
M. Luysberg ,
P. Hapke ,
R. Carius ,
F. Finger
.
Structure and growth of hydrogenated microcrystalline silicon: investigation by transmission electron microscopy and Raman spectroscopy of films grown at different plasma excitation frequencies.
Philos. Mag. A
,
31 -
47
-
7)
-
D.L. Staebler ,
C.R. Wronski
.
Reversible conductivity charge in discharge-produced amorphous Si.
Appl. Phys. Lett.
,
292 -
294
-
8)
-
M. Faraji ,
S. Gokhale ,
S.M. Choudhari ,
M.G. Takwale ,
S.V. Ghaisas
.
High mobility hydrogenated and oxygenated microcrystalline silicon as a photosensitive material in photovoltaic applications.
Appl. Phys. Lett.
,
3289 -
3291
-
9)
-
M. Luysberg ,
C. Scholten ,
L. Houben ,
R. Carius ,
F. Finger ,
O. Vetterl
.
Structural properties of microcrystalline Si solar cells.
Mater. Res. Soc. Symp. Proc.
-
10)
-
E. Vallat-Sauvain ,
U. Kroll ,
A. Shah ,
J. Pohl
.
Evolution of the microstructure in microcrystalline silicon prepared by very high frequency glow-discharge using hydrogen dilution.
J. Appl. Phys.
,
6 ,
3137 -
3142
-
11)
-
O. Vetterl ,
R. Carius ,
L. Houben ,
C. Scholten ,
M. Luysberg ,
A. Lambertz ,
F. Finger ,
H. Wagner
.
(2000)
Mater. Res. Soc. Symp. Proc..
-
12)
-
J.K. Rath
.
Sol. Energy Mater. Sol. Cells.
Sol. Energy Mater. Sol. Cells
-
13)
-
R.W. Collins ,
B.Y. Yang
.
In situ ellipsometry of thin-film deposition: Implications for amorphous and microcrystalline Si growth.
J. Vac. Sci. Technol. B
,
1155 -
1164
-
14)
-
D. Will ,
C. Lerner ,
W. Fuhs ,
K. Lips
.
Transport and recombination channels in undoped microcrystalline silicon studied by ESR and EDMR.
Mat. Res. Soc. Symp. Proc.
,
361 -
366
-
15)
-
A. Mück ,
U. Zastrow ,
O. Vetterl ,
B. Rech ,
A. Benninghoven ,
P. Bertrand ,
H.-N. Migeon ,
H.W. Werner
.
(2000)
, Secondary ion mass spectrometry SIMS XII.
-
16)
-
F. Finger ,
J. Müller ,
C. Malten ,
H. Wagner
.
Electronic states in hydrogenated microcrystalline silicon.
Philos. Mag. B
,
805 -
830
-
17)
-
F. Finger ,
S. Klein ,
T. Dylla ,
A.L. Baia Neto ,
O. Vetterl ,
R. Carius
.
Defects in microcrystalline silicon prepared with hot wire CVD.
Mater. Res. Soc. Symp. Proc.
-
18)
-
S. Klein ,
F. Finger ,
R. Carius ,
T. Dylla ,
B. Rech ,
M. Grimm ,
L. Houben ,
M. Stutzmann
.
Intrinsic microcrystalline silicon by hot-wire CVD for thin film solar cells.
Thin Solid Films
-
19)
-
C. Ross ,
J. Herion ,
H. Wagner
.
Nucleation and growth analysis of microcrystalline silicon by scanning probe microscopy: substrate dependence, local structural and electronic properties of as-grown surfaces.
J. Non-Cryst. Solids
,
69 -
73
-
20)
-
T. Brammer ,
H. Stiebig
.
Defect density and recombination lifetime in microcrystalline silicon absorbers of highly efficient thin-film solar cells determined by numerical device simulations.
J. Appl. Phys.
-
21)
-
F. Shimura
.
(1994)
Semiconductors and Semimetals, Oxygen in silicon.
-
22)
-
S. Klein ,
J. Wolff ,
F. Finger ,
R. Carius ,
H. Wagner ,
M. Stutzmann
.
Microcrystalline silicon prepared by hot-wire chemical vapour deposition for thin film solar cell applications.
Jpn. J. Appl. Phys. 2, Lett.
,
L10 -
L12
-
23)
-
O. Vetterl ,
F. Finger ,
R. Carius ,
P. Hapke ,
L. Houben ,
O. Kluth ,
A. Lambertz ,
A. Mück ,
B. Rech ,
H. Wagner
.
Intrinsic microcrystalline silicon: a new material for photovoltaics.
Sol. Energy Mater. Sol. Cells
,
97 -
108
-
24)
-
S. Klein ,
F. Finger ,
R. Carius ,
B. Rech ,
L. Houben ,
M. Luysberg ,
M. Stutzmann
.
High efficiency thin film solar cells with intrinsic microcrystalline silicon prepared by hot wire CVD.
Mater. Res. Soc. Symp. Proc.
-
25)
-
O. Vetterl ,
A. Gross ,
T. Jana ,
S. Ray ,
A. Lambertz ,
R. Carius ,
F. Finger
.
Changes in electric and optical properties of intrinsic microcrystalline silicon upon variation of the structural composition.
J. Non-Cryst. Solids.
,
772 -
777
-
26)
-
L. Houben ,
C. Scholten ,
M. Luysberg ,
O. Vetterl ,
F. Finger ,
R. Carius
.
Growth of microcrystalline nip Si solar cells: role of local epitaxy.
J. Non-Cryst. Solids
,
1189 -
1193
-
27)
-
P. Kanschat ,
K. Lips ,
R. Brüggemann ,
A. Hierzenberger ,
I. Sieber ,
W. Fuhs
.
(1998)
Mater. Res. Soc. Symp. Proc..
-
28)
-
M. Stutzmann
.
The defect density in amorphous silicon.
Philos. Mag. B
,
531 -
546
-
29)
-
P. Torres ,
J. Meier ,
R. Flückiger ,
U. Kroll ,
J.A. Anna Selvan ,
H. Keppner ,
A. Shah ,
S.D. Littlewood ,
I.E. Kelly ,
P. Giannoules
.
Device grade microcrystalline silicon owing to reduced oxygen contamination.
Appl. Phys. Lett.
,
1373 -
1375
-
30)
-
N. Nickel ,
M. Rakel
.
Hydrogen-induced metastable changes in the electrical conductivity of microcrystalline silicon.
Phys. Rev. B
,
041301/1 -
4
-
31)
-
N. Kniffler ,
B. Schröder ,
J. Geiger
.
Vibrational spectroscopy of hydrogenated evaporated amorphous silicon films.
J. Non-Cryst. Solids
,
153 -
163
-
32)
-
T. Kamei ,
T. Wada ,
A. Matsuda
.
(2001)
Mater. Res. Soc. Symp. Proc..
-
33)
-
S. Klein ,
F. Finger ,
R. Carius ,
H. Wagner ,
M. Stutzmann
.
Intrinsic amorphous and microcrystalline silicon by hot-wire-deposition for thin film solar cell applications.
Thin Solid Films
,
305 -
309
http://iet.metastore.ingenta.com/content/journals/10.1049/ip-cds_20030636
Related content
content/journals/10.1049/ip-cds_20030636
pub_keyword,iet_inspecKeyword,pub_concept
6
6