Measurement of harmonic distortion and Skewness of stator current of induction motor at crawling in Clarke plane
- Author(s): Surajit Chattopadhyay 1 ; Aveek Chattopadhyaya 2 ; Samarjit Sengupta 3
-
-
View affiliations
-
Affiliations:
1:
Electrical Engineering Department, Ghani Khan Choudhury Institute of Engineering & Technology (under Ministry of H.R.D., Government of India), Malda, West Bengal, India;
2: Supreme Knowledge Foundation, West Bengal University of Technology, Mankundu, Hooghly, West Bengal, India;
3: Department of Applied Physics, University of Calcutta, 92 APC Road, Kolkata 700009, India
-
Affiliations:
1:
Electrical Engineering Department, Ghani Khan Choudhury Institute of Engineering & Technology (under Ministry of H.R.D., Government of India), Malda, West Bengal, India;
- Source:
Volume 8, Issue 6,
November 2014,
p.
528 – 536
DOI: 10.1049/iet-smt.2013.0082 , Print ISSN 1751-8822, Online ISSN 1751-8830
This study deals with measurement of harmonic distortion and Skewness of stator current in Clarke plane at crawling of induction motor. Three-phase current signals have been transformed into Clarke plane. Dominancy of seventh harmonic is observed by assessing maxima and minima of stator current Concordia in Clarke plane. Specific reference signals having sinusoidal nature and different frequencies are defined and then areas covered by the real system data with the reference signal have been determined, wherefrom individual contributions of fundamental waveform and harmonic components are measured separately and total harmonic distortion factors are determined. Then wavelet decomposition of stator current is done in Clarke plane, wherefrom, signals are assessed with the help of Skewness of approximate coefficient in Clarke plane. Significant differences are noted between those parameters found during crawling and that of normal condition which may be useful in detection of such fault.
Inspec keywords: power system measurement; fault diagnosis; harmonic distortion; stators; induction motors; singular value decomposition; waveform analysis; approximation theory
Other keywords: harmonic distortion measurement; stator current; signal assessment; fault detection; induction motor; Clarke plane; wavelet decomposition; harmonic components; skewness measurement; coefficient approximation; crawling; normal condition
Subjects: Linear algebra (numerical analysis); Power supply quality and harmonics; Signal processing and detection; Power system measurement and metering; Interpolation and function approximation (numerical analysis); Asynchronous machines
References
-
-
1)
-
6. Bedekar, P.P., Bhide, S.R., Kale, V.S.: ‘Fault section estimation in power system using Hebb's rule and continuous genetic algorithm’, Int. J. Electr. Power Energy Syst., 2011, 33, (3), pp. 457–465 (doi: 10.1016/j.ijepes.2010.10.008).
-
-
2)
-
4. Kumar, P., Jamil, M., Thomas, M.S., Moinuddin, A.: ‘Sensitivity analysis of fault quantities’, Int. J. Electr. Power Energy Syst., 2000, 22, (2), pp. 147–153 (doi: 10.1016/S0142-0615(98)00053-2).
-
-
3)
-
15. Lu, B., Paghda, M.: ‘Induction motor rotor fault diagnosis using wavelet analysis of one-cycle average power’. Twenty-Third Annual IEEE Applied Power Electronics Conf. and Exposition, APEC 2008, Austin, TX, 24–28 February 2008, pp. 1113–1118.
-
-
4)
- S.M.A. Cruz , A.J. Marques Cardoso . Stator winding fault diagnosis in three-phase synchronous and asynchronous motors, by the extended Park's vector approach. IEEE Trans. Ind. Appl. , 1227 - 1233
-
5)
- S. Hua , C. Kil To . Induction machine condition monitoring using neural network modeling. IEEE Trans. Ind. Electron. , 241 - 249
-
6)
-
8. Mehla, N., Dahiya, R.: ‘An approach of condition monitoring of induction motor using MCSA’, Int. J. Syst. Appl. Eng. Dev., 2007, 1, (1), pp. 13–17.
-
-
7)
-
33. Chattopadhyay, S., Mitra, M., Sengupta, S.: ‘Area based mathematical model for harmonic distortion’. POWERCON 2008, Int. Conf. power system organized by IEEE, New Delhi, 12–15 October 2008.
-
-
8)
- F. Zidani , M. El Hachemi Benbouzid , D. Diallo , M.S. NaïT-Saïd . Induction motor stator faults diagnosis by a current Concordia pattern-based fuzzy decision system. IEEE Trans. Energy Convers. , 4 , 469 - 475
-
9)
-
9. Douglas, H., Pillay, P.: ‘The impact of wavelet selection on transient motor current signature analysis’. IEEE International Conference Electric Machines and Drives, San Antonio, TX, 15-15 May 2005, pp. 80–85.
-
-
10)
-
7. Cusido, J., Romeral, L., Ortego, J.A., Rosero, J.A., Espinosa, A.G.: ‘Fault detection in induction machines using power spectral density in wavelet decomposition’, IEEE Trans. Ind. Electr., 2008, 55, (2), pp. 633–643 (doi: 10.1109/TIE.2007.911960).
-
-
11)
-
8. Mohammed, O.A., Abed, N.Y., Ganu, S.: ‘Modeling and characterization of induction motor internal faults using finite element and discrete wavelet transform’, IEEE Trans. Magn., 2006, 42, (10), pp. 3434–3436 (doi: 10.1109/TMAG.2006.879091).
-
-
12)
-
2. Sehoen, R.R., Lin, B.K., Habetler, T.G., Schlag, J.H., Farag, S.: ‘An unsupervised on-line system for Induction motor fault detection using stator current monitoring’, IEEE Trans. Ind. Appl., 1995, 31, pp. 23–28.
-
-
13)
-
13. Chattopadhyay, S., Mitra, M., Sengupta, S.: ‘A novel approach for diagnosis of current unbalance at the terminals of a three-phase induction motor’. Proc. of MS2004 – Int. Conf. on Modeling and Simulation by AMSE (France), Lyon France, July 2004, pp. 3.22–3.25.
-
-
14)
-
26. Chattopadhyay, S., Mitra, M., Sengupta, S.: ‘Intelligent power quality monitoring in an electric power system’. Best of 2004 – Volume on Modeling and Simulation, AMSE, France, 2004, pp. 146–156.
-
-
15)
-
3. Benbouzid, M.E.H., Beguenane, R.: ‘Induction motor diagnostics via stator current monitoring’. Proc. of Int. Conf. on Maintenance and Reliability, Knoxville, TN, 1997, vol. 1, pp. 36.01–36.10.
-
-
16)
-
24. Chattopadhyay, S., Mitra, M., Sengupta, S.: ‘Harmonic analysis in a three-phase system using park transformation technique’, AMSE Int. J. Model. Simul., France, n0 –3, Modeling-A, 2007, 80, pp. 42–58.
-
-
17)
-
16. Chattopadhyay, S., Mitra, M., Sengupta, S.: ‘Electric power quality’ (Springer, 2011, 1st edn.).
-
-
18)
-
29. Chattopadhyay, S., Mitra, M., Sengupta, S.: ‘Area based approach in power quality assessment’, Int. J. Power Manag. Electron., ID-147359, May, 2008, pp. 6, ISSN: 16876679.
-
-
19)
-
32. Chattopadhyay, S., Mitra, M., Sengupta, S.: ‘Single cycle mathematical model for harmonic power’. Proc. of Int. Conf. Modeling and Simulation (MS'07), Kolkata, India, 3–5 December 2007, pp. 38–42.
-
-
20)
- F. Filippetti , G. Franceschini , C. Tassoni , P. Vas . A.I. techniques in i.m. diagnosis including the speed ripple effect. IEEE Trans. Ind. Appl. , 1 , 98 - 108
-
21)
- D. Diallo , M. El Hachemi Benbouzid , D. Hamad , X. Pierre . Fault detection and diagnosis in an induction machine drive: a pattern recognition approach based on Concordia stator mean current vector. IEEE Trans. Energy Convers. , 3 , 512 - 519
-
22)
- X. Lin , H. Weng , B. Wang . A generalize method to improve the location accuracy of the single-ended sampled data and lumped parameter model based fault locators. Int. J. Electr. Power Energy Syst. , 5 , 201 - 205
-
23)
-
31. Chattopadhyay, S., Mitra, M., Sengupta, S.: ‘Harmonic analysis in a three-phase system using park transformation technique’, AMSE International Journal on Modeling and Simulation, France, n0 –3, Modeling-A, 2007, 80, pp. 42–58.
-
-
24)
-
18. Caldara, S., Nuccio, S., Galluzzo, G.R., Trapanese, M.: ‘A fuzzy diagnostic system: application to linear induction motor drives’. Proc. IEEE Instrum. Meas. Technol. Conf., Ottawa, ON, Canada, 1997, vol. 1, pp. 257–262.
-
-
25)
-
38. Cusido, J., Jornet, A., Romeral, L., Ortega, J.A., Garcia, A.: ‘Wavelet and PSD as a fault detection technique’. Proc. of IEEE Instrumentation and Measurement Technology Conf., (ITMC 2006), Sorrento, Italy, 24–27 April 2006, pp. 1397–1400.
-
-
26)
-
39. Chattopadhyaya, A., Chattopadhyay, S., Sengupta, S.: ‘Wavelet decomposition base Skewness and Kurtosis analysis for assessment of crawling of an induction motor in Clarke plane’. Michael Faraday IET India Summit 2012 by IET Kolkata Network in Kolkata, 25 November 2012, pp. 283–286.
-
-
27)
- R. Supangat , N. Ertugrul , W.L. Soong , D.A. Gray , C. Hansen , J. Grieger . Detection of broken rotor bars in induction motor using starting-current analysis and effects of loading. IEE Proc. Electr. Power Appl. , 6 , 848 - 855
-
28)
-
30. Zhang, Y.-G., Wang, Z.-P., Zhang, J.-F., Ma, J.: ‘Fault localization in electrical power systems: a pattern recognition approach’, Int. J. Electr. Power Energy Syst., 2011, 33, (3), pp. 791–798 (doi: 10.1016/j.ijepes.2011.01.018).
-
-
29)
-
20. Samantaray, S.R., Dash, P.K.: ‘Pattern recognition based digital relaying for advanced series compensated line’, Int. J. Electr. Power Energy Syst., 2008, 30, (2), pp. 102–112 (doi: 10.1016/j.ijepes.2007.06.018).
-
-
30)
-
26. Nejjari, H., Benbouzid, M.E.H.: ‘Monitoring and diagnosis of induction motors electrical faults using a current Park's vector pattern learning approach’, IEEE Trans. Ind. Appl., 2000, 36, (3), pp. 730–735 (doi: 10.1109/28.845047).
-
-
31)
-
31. Tavakoli Bina, M., Kashefi, A.: ‘Three-phase unbalance of distribution systems: complementary analysis and experimental case study’, Int. J. Electr. Power Energy Syst., 2011, 33, (4), pp. 817–826 (doi: 10.1016/j.ijepes.2010.12.003).
-
-
32)
- M.E.H. Benbouzid . A review of induction motor signature analysis as a medium for fault detection. IEEE Trans Ind. Electron. , 5 , 984 - 993
-
33)
-
27. Chattopadhyay, S., Mitra, M., Sengupta, S.: ‘Harmonic power in Clarke plane’, Journal of Institute of Engineers (India): Series – Electrical Engineering, 2010, 91, pp. 23–28.
-
-
34)
- S. Suja , J. Jerome . Pattern recognition of power signal disturbances using S transform and TT transform. Int. J. Power Energy Syst. , 1 , 37 - 53
-
35)
-
30. Chattopadhyay, S., Mitra, M., Sengupta, S.: ‘Area based approach for three phase power quality assessment in Clarke plane’, J. Electr. Syst., 2008, 4, (3), pp. 60–76.
-
-
36)
-
12. Rodriguez-Donate, C., Romero-Troncoso, R.J., Garcia-Perez, A., Razo-Montes, D.A.: ‘FPGA based embedded system for induction motor failure monitoring at the start-up transient vibrations with wavelets’. IEEE Int. Symp. Industrial Embedded Systems, SIES 2008, Le Grande Motte, France, 11–13 June 2008, pp. 208–214.
-
-
37)
- J.-H. Jung , J.-J. Lee , B.-H. Kwon . Online diagnosis of induction motors using MCSA. IEEE Trans. Ind. Electron. , 6 , 1842 - 1852
-
38)
-
32. Wang, C., Jia, Q.-Q., Li, X.-B., Dou, C.-X.: ‘Fault location using synchronized sequence measurements’, Int. J. Electr. Power Energy Syst., 2008, 30, (2), pp. 134–139 (doi: 10.1016/j.ijepes.2007.06.027).
-
-
39)
-
10. Fenger, M., Lloyd, B.A., Thomson, W.T.: ‘Development of a tool to detect faults in induction motors via current signature analysis’. Cement Industry Technical Conf., 2003. Conf. Record. IEEE-IAS/PCA 2003, Dallas, TX, USA, 4–9 May 2003, pp. 37–46.
-
-
1)